乙炔/空气预混火焰中CO添加对炭黑生成影响的数值分析

doi:10.3866/PKU.WHXB20100823

物理化学学报 >> 2010, Vol. 26 >> Issue (08): 2121-2129.doi: 10.3866/PKU.WHXB20100823

乙炔/空气预混火焰中CO添加对炭黑生成影响的数值分析

蒋勇, 邱榕

中国科学技术大学火灾科学国家重点实验室, 合肥 230026

收稿日期:2010-02-03 修回日期:2010-04-08 发布日期:2010-07-23
通讯作者: 蒋勇 E-mail:yjjiang@ustc.edu.cn
基金资助:
国家自然科学基金(50876097)和教育部新世纪优秀人才支持计划(NCET-06-0546)资助项目

Numerical Analysis of the Effect of Carbon Monoxide Addition on Soot Formation in an Acetylene/Air Premixed Flame

JIANG Yong, QIU Rong

State Key Laboratory of Fire Science, University of Science and Technology of China, Hefei 230026, P. R. China

Received:2010-02-03 Revised:2010-04-08 Published:2010-07-23
Contact: JIANG Yong E-mail:yjjiang@ustc.edu.cn
Supported by:
The project was supported by the National Natural Science Foundation of China (50876097) and New Century Excellent Talents in University of China (NCET-06-0546).

摘要/Abstract

摘要：

针对乙炔/空气预混火焰中CO添加对炭黑生成的影响进行了详细的数值模拟. 通过对含有不同CO添加量的火焰的模拟结果比较, 研究CO添加的温度和化学作用对于炭黑形成的影响. 计算结果显示CO添加使炭黑的生成单调下降. 炭黑体积分数和成核速率随着温度的升高而增加, 到达一个阈值后, 再随温度的升高而减少. 从炭黑生成的H-萃取角度来看, 由于反应OH+CO=CO₂+H的向右速率增加, H原子增加以及OH自由基减少, CO添加会激发炭黑生成. 从炭黑生成的C-添加机理来看, CO添加减小了C₂H₂的消耗速率, CO添加也有助于炭黑生成, 但CO添加降低了燃料中C₂H₂的体积分数, 使得炭黑表面增长速率降低.

关键词: 炭黑, 乙炔, 一氧化碳, 燃料改进, 模化

Abstract:

The effect of carbon monoxide addition on soot formation in an acetylene/air premixed flame was investigated by detailed numerical simulation. This work focused on both the temperature effect and chemical effect of carbon monoxide addition on soot formation by comparing the results of flames with different CO contents. We find that the addition of carbon monoxide consistently reduces the formation of soot. The soot volume fraction and nucleation rate increase until a threshold temperature is reached and then decrease as the temperature increases. Considering that soot formation took place at the active site by H-abstraction mechanism, the addition of CO promotes the formation of soot. The concentration of H radicals increases and the concentration of OH radicals decreases because of the increased forward rate of the reaction OH+CO=CO₂+H. For soot formation to occur by the C-addition mechanism, the degradation rates of C₂H₂ tends to decrease and this promotes the formation of soot along with CO addition. On the other hand, the addition of CO may greatly reduce the volume fraction of C₂H₂ in fuel resulting in a lower surface growth rate.

Key words: Soot, Acetylene, Carbon monoxide, Fuel enrichment, Modeling

蒋勇, 邱榕. 乙炔/空气预混火焰中CO添加对炭黑生成影响的数值分析[J]. 物理化学学报, 2010, 26(08), 2121-2129. doi: 10.3866/PKU.WHXB20100823

JIANG Yong, QIU Rong. Numerical Analysis of the Effect of Carbon Monoxide Addition on Soot Formation in an Acetylene/Air Premixed Flame[J]. Acta Phys. -Chim. Sin. 2010, 26(08), 2121-2129. doi: 10.3866/PKU.WHXB20100823

链接本文: https://www.whxb.pku.edu.cn/CN/10.3866/PKU.WHXB20100823

https://www.whxb.pku.edu.cn/CN/Y2010/V26/I08/2121

参考文献

[1]. Yamamoto, M.; Duan, S.; Senkan, S. Combust. Flame, 2007, 151: 532
[2]. Kunioshi, N.; Komori, S.; Fukutani, S. Combust. Flame, 2006, 147: 1
[3]. Joo, H. I.; Gülder, õ. L. Proc. Combust. Inst., 2009, 32: 769
[4]. Kim, Y.; Hatsushika, H.; Muskett, R. R.; Yamazaki, K. Atmos. Environ., 2005, 39: 3513
[5]. Xu, F.; Sunderland, P. B.; Faeth, G. M. Combust. Flame, 1997, 108: 471
[6]. Guo, H.; Smallwood, G. J.; Liu, F.; Ju, Y.; Gülder, õ. L. Proc. Combust. Inst., 2005, 30: 303
[7]. Ren, J. Y.; Qin, W.; Egolfopoulos, F. N.; Tsotsis, T. T. Combust. Flame, 2001, 124: 717
[8]. Coppens, F. H. V.; Ruyck, J. D.; Konnov, A. A. Combust. Flame, 2007, 149: 409
[9]. Guo, H.; Smallwood, G. J.; Gülder, õ. L. Proc. Combust. Inst., 2007, 31: 1197
[10]. Wu, C. Y.; Chao, Y. C.; Cheng, T. S.; Chen, C. P.; Ho, C. T. Combust. Flame, 2009, 156: 362
[11]. Gülder, õ. L.; Snelling, D. R.; Sawchuk, R. A. Proc. Combust. Inst., 1996, 26: 2351
[12]. Glassman, I. Proc. Combust. Inst., 1998, 27: 1589
[13]. Guo, H.; Liu, F.; Smallwood, G. J.; Gülder, õ. L. Proc. Combust. Inst., 2002, 29: 2359
[14]. Guo, H.; Liu, F.; Smallwood, G. J.; Gülder, õ. L. Combust. Flame, 2006, 145: 324
[15]. Pandey, P.; Pundir, B. P.; Panigrahi, P. K. Combust. Flame, 2007, 148: 249
[16]. Guo, H.; Thomson, K. A.; Smallwood, G. J. Combust. Flame, 2009, 156: 1135
[17]. Du, D. X.; Axelbaum, R. L.; Law, C. K. Combust. Flame, 1995, 102: 11
[18]. Bhatt, J. S.; Lindstedt, R. P. Proc. Combust. Inst., 2009, 32: 713
[19]. Appel, J.; Bockhorn, H.; Frenklach, M. Combust. Flame, 2000, 121: 122
[20]. Kazakov, A.; Frenklach, M. Combust. Flame, 1998, 114: 484
[21]. Frenklach, M. Chem. Eng. Sci., 2002, 57: 2229
[22]. Lindstedt, R. P.; Louloudi, S. A. Proc. Combust. Inst., 2005, 30: 775
[23]. Zhao, B.; Yang, Z.; Johnston, M. V.; Wang, H.; Wexler, A. S.; Balthasar, M.; Kraft, M. Combust. Flame, 2003, 133: 173
[24]. Smooke, M. D.; McEnally, C. S.; Pfefferle, L. D.; Hall, R. J.; Colket, M. B. Combust. Flame, 1999, 117: 117
[25]. Park, S. H.; Rogak, S. N.; Bushe, W. K.; Wen, J. Z.; Thomson, M. J. Combust. Theor. Model., 2005, 9: 499
[26]. Zhang, Q.; Guo, H.; Liu, F.; Smallwood, G. J.; Thomson, M. J. Proc. Combust. Inst., 2009, 32: 761
[27]. Mueller, M. E.; Blanquart, G.; Pitsch, H. Proc. Combust. Inst., 2009, 32: 785
[28]. Blanquart, G.; Pitsch, H. Combust. Flame, 2009, 156: 1614
[29]. Jiang, Y.; Qiu, R.; Fan, W. C. Journal of Combustion Science and Technology, 2005, 11:218. [蒋勇, 邱榕, 范维澄. 燃烧科学与技术, 2005, 11: 218]
[30]. Bowman, C. T.; Hanson, R. K.; Davidson, D. F.; Gardiner, W. C.; Lissianski, V.; Smith, G. P.; Golden, D. M.; Frenklach, M.; Goldenberg, M. GRI 2.11 detailed mechanism. http://www.me.berkeley.edu/gri_mech/, Berkley CA, USA
[31]. Marinov, N. M.; Pitz, W. J.; Westbrook, C. K.; Vincitore, A. M.; Castaldi, M. J.; Senkan, S. M.; Melius, C. F. Combust. Flame, 1998, 114: 192
[32]. SkjΦth-Rasmussen, M.; Glarborg, P.; Φstberg, M.; Johannessen, J.; Livbjerg, H.; Jensen, A.; Christensen, T. Combust. Flame, 2004, 136: 91
[33]. Koylü, U. õ.; Faeth, G. M.; Farias, T. L.; Carvalho, M. G. Combust. Flame, 1995, 100: 621
[34]. Kee, R. J.; Rupley, F. M.; Miller, J. A. Chemkin-II: a Fortran chemical kinetics package for the analysis of gas-phase chemical kinetics. Report SAND89-8009, Sandia, 1989
[35]. Kee, R. J.; Grcar, J. F.; Smooke, M. D.; Miller, J. A. PREMIX: a Fortran program for modeling steady laminar one-dimensional premixed flames. Report SAND85-8240, Sandia, 1985
[36]. Wang, H.; Frenklach, M. Combust. Flame, 1997, 110: 173
[37]. Wieschnowsky, U.; Bockhorn, H.; Fetting, F. Proc. Combust. Inst., 1989, 22: 343
[38]. Castaldi, M. J.; Senkaw, S. M. Combust. Sci. Technol., 1996, 116: 167
[39]. Tregrossi, A.; Ciajolo, A.; Barbella, R. Combust. Flame, 1999, 117: 553

乙炔/空气预混火焰中CO添加对炭黑生成影响的数值分析

Numerical Analysis of the Effect of Carbon Monoxide Addition on Soot Formation in an Acetylene/Air Premixed Flame

PDF

赞

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

Metrics

推荐阅读 0

[1]	方洪燕, 江静静, 王定胜, 刘向文, 朱敦如, 李亚栋. 乙炔半加氢催化剂设计[J]. 物理化学学报, 2023, 39(10): 2305030 - .
[2]	姜蓓, 孙靖宇, 刘忠范. 石墨烯晶圆的制备：从高品质到规模化[J]. 物理化学学报, 2022, 38(2): 2007068 - .
[3]	黄小雄, 马英杰, 智林杰. 超薄氮掺杂碳纳米片负载单原子镍用于高效电催化还原二氧化碳[J]. 物理化学学报, 2022, 38(2): 2011050 - .
[4]	刘学伟, 牛莹, 曹瑞雄, 陈晓红, 商红岩, 宋怀河. 石墨烯包覆天然球形石墨作为锂离子电池的负极材料，是否需要乙炔黑导电剂？[J]. 物理化学学报, 2022, 38(2): 2012062 - .
[5]	李天, 郝晓杰, 白莎, 赵宇飞, 宋宇飞. 单层类水滑石纳米片的可控合成及规模生产展望[J]. 物理化学学报, 2020, 36(9): 1912005 - .
[6]	周远, 韩娜, 李彦光. 钯基纳米材料电化学还原二氧化碳研究进展[J]. 物理化学学报, 2020, 36(9): 2001041 - .
[7]	潘志明,刘明辉,牛萍萍,郭芳松,付贤智,王心晨. Ni₂P纳米片用于光催化二氧化碳还原[J]. 物理化学学报, 2020, 36(1): 1906014 - .
[8]	傅之丹,臧佳欣,叶青,程水源,康天放. OL负载Cu催化剂及其催化氧化CO及乙酸乙酯性能[J]. 物理化学学报, 2017, 33(9): 1855 -1864 .
[9]	高晓平,郭章龙,周亚男,敬方梨,储伟. 锐钛矿型TiO₂担载的Pd催化剂用于乙炔选择加氢的催化性能及其表征[J]. 物理化学学报, 2017, 33(3): 602 -610 .
[10]	郑雁公,朱丽娜,李晗宇,简家文,杜海英. 氧化钯作为电位型传感器中敏感电极的工作机理[J]. 物理化学学报, 2017, 33(3): 573 -581 .
[11]	祁彦宇,孙晓环,常兴茂,康蕊,刘凯强,房喻. 一种新型对苯乙炔基苯衍生物：荧光行为与传感应用[J]. 物理化学学报, 2016, 32(1): 373 -379 .
[12]	李晓坤,马冬冬,郑燕萍,张宏,丁丁,陈明树,万惠霖. TiO_x/SiO₂复合载体上高分散Au催化剂的CO氧化性能[J]. 物理化学学报, 2015, 31(9): 1753 -1760 .
[13]	王沾祺, 周志明, 张锐, 李莉, 程振民. Pd-Cu/γ-Al₂O₃催化苯乙炔选择性加氢反应[J]. 物理化学学报, 2014, 30(12): 2315 -2322 .
[14]	李娜, 陈秋艳, 罗孟飞, 鲁继青. Pt/TiO₂催化剂上CO氧化反应动力学研究[J]. 物理化学学报, 2013, 29(05): 1055 -1062 .
[15]	陈忠秀, 曹晨, 邓少平. 聚联乙炔囊泡负载的Bola型两亲分子识别三聚氰胺过程中Chaotrope促进型显色机制及热力学[J]. 物理化学学报, 2012, 28(06): 1320 -1328 .